off season boat maintenence? - Striper Talk Striped Bass Fishing, Surfcasting, Boating

niko · 10-15-2006, 07:36 AM

hi everyone. i could use a little help w/ recomended maint. the boat is 2 yrs old, 500 hrs on a 115 merc. last year all i did was oil, plugs - basic stuff. it runs great but is it time for a service visit? or if it ain't broke don't fix it? i'm going to swap out the batts and the b-pump. what else am i missing? also - full gas tank or empty?

beamie · 10-15-2006, 07:48 AM

Niko,

Good batteries should last you more than 2 years, more like 3-5. You can usually see the battery bulging when the plates start failing, then it is a no brainer. You can give them a load test. If they remained trickle charged thru the winter they should be fine.

Lots of literature out about the new gas....the latest theory is near MT tanks for the winter with E10 gas, some kind of stailizer wouldn't be bad either for the small amount of gas remaining. I have read that a product called Startron from Starbrite is good for the water/gas interface which is more of a problem no a days.

ProfessorM · 10-15-2006, 08:28 AM

Water pump and thermostat

Van · 10-18-2006, 07:29 AM

Quote:

Originally Posted by niko

if it ain't broke don't fix it?

also - full gas tank or empty?

My ficht rude is an 01' I've had since 00' never done the thermostats or water pump. I don't know the hours, but I still may not do those changes next year.

As for the gas. I've been talking to many and reading alot (hull truth has knowledgable members). So far it seems get it as empty as possible and add an additive for E10 gas. Not sure which one yet.
AND if possible run the gas out of the engine (fuel rails, carbs whatever)

niko · 10-18-2006, 01:58 PM

thanks for the input gents, paul

rjinhull · 10-30-2006, 06:38 PM

water pump every 2 years (cheep insurance)

rjinhull · 10-30-2006, 06:42 PM

i have heard to keep gass in the carbs to keep the varnish down

I just run fuel stabilizer on the last run to get it through the system
Or run it on the trailer (with ear muffs)

Roger · 10-31-2006, 08:10 AM

Quote:

Originally Posted by niko

i'm going to swap out the batts and the b-pump.

Unless you've regularly run down the batteries and not topped them off, they should last a few more years.

Re: bilge pump - I'd add a second pump instead of swapping one out. They usually last a long time, but then again I've had them fail in a year too (rare).

Mr. Sandman · 10-31-2006, 06:37 PM

What goes on bilge pumps is the float switch. I have had brand new ones out of the box not work. If they stick, scrap it, they are not worth the time to #^&#^&#^&#^& around with them.

I would change the impeller for the waterpump. I have this done *every* season...It is just rubber, and the heat, salt and friction takes it toll on it. While you are at it change the thermostat. (When these things go it is generally not at good time...why cheap out? Don't wait for it to crap out.)

Of course all oil, gearcase and fuel/oil filters need to be changed as well. I chage all that stuff every 100 hours.

I find those cheap live bait pumps crap out often...when you replace them, get a good one and it will last much longerand run better.

Fish On · 10-31-2006, 08:02 PM

Personally I would go to your local merc dealer and buy the manual for that engine if you don't already have it. i would review the recommended maint. and combine those instructions with the advice you get here to make your own decisions. You should be familiar with your engines manual anyway. If you go out any distance I recommend you keep the manual on your boat along with an assortment of tools capable of making basic repairs/adjustments. Hopefully you never need them. Good luck.

ChrisH · 11-01-2006, 07:16 PM

Good advice by everyone, water pumps every two years is cheap insurance. Change your lower unit gear oil and have the lower unit pressure tested to see if the seals are good, winter is the best time to have work done on your lower unit.

niko · 11-03-2006, 03:34 PM

thanks for all the help everyone

Newboater · 11-22-2006, 01:47 PM

Each end of year I service the 115 Yamaha outboard myself. 1/4 or less gas in tank, double recommended stabilizer. Drain oil, new filter, new oil. Lower unit gear drained, new thick stuff. Pull plug connectors and put a little oil in cylinders. Turn engine over without plugs attached to move the oil around. Batteries in basement and trickle charge every 2 months. Full tank in spring and go fishing.

Every 2nd year to dealer for check over and new filters. Ethanol can clean your tank and tubes and put debris in filters. New grease for fittings and steering etc.

Start it up in April and go fishing.

NewBoater